Quality ignition coil manufacturer
Auto ignition coil manufacturer in China: Gasoline vehicles are usually powered by a simple 12-volt DC battery. This is enough voltage to engage a starter motor and get the engine turning, but it’s not enough for actual combustion. (A spark plug needs around 40,000 volts for combustion.) That’s where the ignition coil comes in. It contains a step-up transformer (also known as a coil pack) to convert that tiny current into quick bursts of several thousand volts at a time. This electricity is then sent to each spark plug in perfect time with the cylinder’s combustion cycle, igniting fuel vapor with oxygen and producing power. Diesel engines notably lack ignition coils because they ignite their fuel using heat and pressure alone. Discover additional details on wholesale ignition coil.
The ignition coil is an important part of a car, Haiyan ignition coil manufacturer will give you a professional introduction to the ignition coil n this blog. The car ignition coil is a crucial component of the internal combustion engine. It is an electronic device that converts the 12 volt battery voltage to around 20,000 volts. The automotive ignition coil has a high-voltage winding and a low-voltage winding. The high voltage winding is connected to the battery terminal, while the low voltage winding is connected to the spark plug wire. When you crank your engine, current flows through the primary windings of your car ignition coil and generates enough power to jump across to secondary windings in order to create a spark at your spark plug wire.
The car coil itself is a transformer, which is like a transformer in a household appliance. When the voltage changes within a specified range, the transformer will not be burned. Usually, the burning of the transformer occurs when the transformer is overloaded. When solving this problem, we must try to find out the cause of the excessive load or the aging of the components. If there is no fire or weak sparks that suddenly occur during driving, an infrared thermometer or hand touch can be used to determine whether the car coil or the ignition module has an internal short circuit or open circuit fault. When the fault is judged, it can also be restarted. Total of 8 R&D personnel in our factory, Haiyan wholesale ignition coil suppliers have more than 15 years of working experience.
The primary winding of an ignition coil will typically contain 150 to 300 turns of wire; the secondary winding will typically contain 15,000 to 30,000 turns of wire, or around 100 times more than the primary winding. The magnetic field is initially created when the vehicle’s electrical system applies approximately 12 volts to the ignition coil’s primary winding. When a spark is required at a spark plug, the ignition system will switch off the current flow to the primary winding, which will cause the magnetic field to collapse. The collapsing magnetic field will induce a voltage into the primary winding in the region of 200 volts; but the voltage induced into the secondary winding will be approximately 100 times greater, around 20,000 volts.
The Kettering ignition system became virtually the only type of ignition system for mass-produced petrol cars, and stayed that way until electronically switched and controlled ignition systems started to replace mechanical ignition systems during the 1970s and 1980s. The basic principle of an ignition coil: To produce the required high voltages, ignition coils make use of the relationships that exist between electricity and magnetism. When an electric current flows through an electrical conductor such as a coil of wire, it creates a magnetic field around the coil (Figure 2). The magnetic field (or, more precisely, magnetic flux) is effectively a store of energy, which can then be converted back into electricity.
The products are produced by Haiyan hardware accessories manufacturer. It is highly resistant to temperature and heat. The manufactured hardware accessories have such merits of as to be used in the area. It is highly resistant to temperature and heat. Haiyan hardware accessories supplier has developed a broad market at home and abroad with its excellent quality, fast delivery, and timely and thoughtful service. It is highly resistant to temperature and heat. See even more details on https://www.hj-auto.com/.
Haiyan car ignition coil suppliers have 200 workers, around 170 work over 4 years, with an independent long-term workflow and productivity, have one department including 30 products technology development and research. Our automotive ignition coil manufacturers cover over 14000 square meters, have been awarded city contracts and keeping promises to units, also we certify ISO9001, and TS16949 for a quality system, truly achieving the quality first, reputation first quality service for our customers at home and abroad. Kindly welcome domestic and overseas patrons to come and guide.